Concrete Zhongke mixer truck is a special truck used to transport concrete used in construction; because of its shape, it is often called snail truck and olive truck. These vehicles are equipped with cylindrical mixing drum to carry the mixed concrete. Today, the old driver will introduce some driving experience to you.

　　1、搅拌车在水泵工作时，禁止空转，连续使用时不要超过15分钟。

　　1. When the mixing truck is working on the water pump, it is forbidden to idle, and it should not be used for more than 15 minutes continuously.

　　2、搅拌车放料前先把出料斗溜槽打湿。放料时把车尽量停在平地上放料。

　　2. Wet the discharge hopper chute before discharging the mixer. When discharging materials, park the vehicle on the flat ground as far as possible.

　　3、卸料不要大意和放料工打好关系。放料时尽量自己看着，免得放料工乱操作放料操作杆，每次罐子正反转中间位子时尽量停一下，保护减速机，托轮等。与放料工打好关系，卸料时也不要睡的太熟，万一工人闹情绪，把你车子放到工地不转罐子，造成闷罐就麻烦了。

　　3. Don't be careless in discharging materials and have a good relationship with the discharging workers. When discharging materials, try to watch by yourself, so as to prevent the discharging workers from operating the discharging operating rod disorderly. Stop as much as possible when the middle position of the tank is in the forward and reverse direction, so as to protect the reducer and supporting wheel. Make a good relationship with the discharging workers, and don't sleep too well when unloading. In case that the workers are in a mood and put your car on the construction site without turning the cans, it will be troublesome for the cans to be stuffy.

　　4、搅拌车水箱的水量要经常保持装满，以备急用，冬季停机后，应将水箱、水泵、水管、搅拌筒内的水放净，并停放在朝阳、不积水的地方，以免冻坏机械。

　　4. The water tank of the mixer truck should always be full in case of emergency. After shutdown in winter, the water in the water tank, water pump, water pipe and mixing drum should be drained completely, and the water should be stored in a place where there is no water in the morning to avoid freezing damage to the machinery.
        

　　5、卸料前让搅拌罐全速运转一两分钟。让混凝土充分搅拌，必要时可以加一些水，让混凝土搅拌得更均匀，也方便卸料。

　　5. Let the mixing tank run at full speed for one or two minutes before discharging. The concrete can be fully mixed, and some water can be added if necessary to make the concrete more uniform and convenient for unloading.

　　6、搅拌车工作完毕，应把搅拌筒内部和车身清洗干净，不能使剩余的混凝土留在筒内。

　　6. After the mixing truck is finished, the interior and body of the mixing drum shall be cleaned, and the remaining concrete shall not be left in the drum.

　　7、 搅拌罐一定要仔细地冲洗干净。洗罐子时一定要仔细的冲洗干净，并把水反复的正反转两次，再放出来，然后一趟时把水箱的水全部放进罐子，再回到站加水彻底清洗罐子。

　　7. The mixing tank must be washed carefully. When washing the tank, be sure to wash it carefully, and turn the water forward and backward twice, and then put it out again. Then put all the water in the tank into the tank, and then return to the station to clean the tank thoroughly.

　　8、搅拌车在冬季应及时安装保温套，并使用防冻液对搅拌车加以保护，根据天气变化更换燃油标号，确保机械的正常使用。

　　8. In winter, the mixer should be installed with insulation sleeve in time, and antifreeze should be used to protect the mixer. The fuel label should be changed according to the weather change to ensure the normal use of machinery.

　　9、在检查、修理搅拌车液压传动部分时，应使发动机和液压泵在没有压力的情况下进行。

　　9. When checking and repairing the hydraulic transmission part of the mixer, the engine and hydraulic pump should be operated without pressure.

　　10、在调整混凝土自动上料搅拌车各部间隙、行程、压力时，应由专职员检查同意；更换机件时，由部长或主管经理签字，否则出现问题后追究有关人员责任。

　　10. When adjusting the clearance, stroke and pressure of each part of the automatic concrete feeding mixer, the full-time safety officer shall check and approve; when replacing the machine parts, the director or the manager in charge shall sign, otherwise, the relevant personnel shall be held responsible for the problems.

　　以上是老司机分享的有关混凝土搅拌车的驾驶要点的介绍，希望对大家有所帮助，如想要了解更多信息请继续关注我们的网站。

　　The above is the introduction of driving points of concrete mixer truck shared by old drivers. I hope it will help you. If you want to know more, please continue to pay attention to our website.