中科聚丰为大家普及一点儿搅拌车的小知识，如下：
Zhongke Jufeng popularizes a little knowledge of mixer truck, as follows:
水泥搅拌车在建筑行业是个经常碰面的小帮手，因为水泥搅拌车的工作效率和质量都很好，也帮我们节约了时间去做别的事情，那么，水泥搅拌车的主要结构有哪些？我们一起来探寻一下吧！
Cement mixer truck is a small helper we often meet in the construction industry, because the work efficiency and quality of cement mixer truck are very good, which also saves us time to do other things. Then, what are the main structures of cement mixer truck? Let's explore it together!
水泥搅拌车的主要结构有哪些：
What are the main structures of cement mixer truck:
水泥搅拌车主要由汽车底盘搅拌筒传动系统供水装置等部分组成。由于技术瓶颈，国产搅拌车的四大件液压马达变量柱塞泵减速机冷却器全部为进口部件。
The cement mixer truck is mainly composed of automobile chassis, mixing drum, transmission system, water supply device, etc. Due to the technical bottleneck, the coolers of the four large hydraulic motor variable piston pump reducer of domestic mixer are all imported parts.
水泥搅拌车组成：二类底盘传动系液压系统机架搅拌罐进出料装置供水系统操纵系人梯等部分。搅拌罐前端与减速机联接安装在机架前台上，后端通过滚道由安装在机架后台的两个托轮支撑。
Composition of cement mixer truck: Class II chassis transmission system, hydraulic system, frame, mixing tank feeding and discharging device, water supply system, operation system, ladder, etc. The front end of the mixing tank is connected with the reducer and installed on the front desk of the rack, and the rear end is supported by two supporting wheels installed on the back of the rack through the raceway.
自上料搅拌车是工地用车，这种车的车型比较大，所以在出车前一定要注意检查，以防万一。
The self loading mixer is a vehicle for the construction site. The model of this vehicle is relatively large, so you must pay attention to inspection before driving, just in case.
细心检查及时发现排除故障。
Check carefully and find and eliminate faults in time.
千万不能让自动上料搅拌车坏在路上，否则出现闷罐就麻烦了，混凝土一般停罐不能超过2个小时，C40往上级别的混凝土基本就不能停。点火之前先检查机油防冻液润滑油和冷却水等，发现不足时，应重新进行添加。车子启动后，再让罐子低速旋转，围绕着车检查轮胎气压，是否有漏气的胎，再用螺丝刀剔掉在胎缝里的石子，检查是否有铁钉之类扎在胎里
Do not let the automatic loading mixer break down on the road, otherwise it will be troublesome to stuffy the tank. Generally, the concrete tank can not be stopped for more than 2 hours, and the C40 concrete can not be stopped. Check the engine oil, antifreeze, lubricating oil and cooling water before ignition. If it is found to be insufficient, add it again. After the car starts, let the can rotate at a low speed, check the tire pressure around the car, check whether there is a leaking tire, and then use a screwdriver to remove the stones in the tire seam and check whether there are iron nails or the like stuck in the tire
再检查灯光，尤其是腰灯，务必保证照着轮胎边缘，工地会经常乱堆放钢筋之类的东西，而胎侧是薄弱的。用抹布擦干净两边的后视镜，窗户玻璃，工地路况复杂，光线不好，视线一定要保证！ 自上料搅拌机
Check the light, especially the waist light, to ensure that it shines on the edge of the tire. The construction site will often pile up reinforcement and other things, and the sidewall is weak. Clean the rear-view mirrors and window glass on both sides with a rag. The road conditions on the construction site are complex and the light is bad. The line of sight must be guaranteed first! Self feeding mixer
保证水箱里有足够的水，有减水剂，因各种原因料太干，没有水添加放不出料的时候，减水剂就是救命稻草了。
Ensure that there is enough water in the water tank and water reducing agent. When the material is too dry for various reasons and there is no water to add, the water reducing agent is a life-saving straw.
确认搅拌罐处于停止状态，因为发动机启动时万一罐子处于高速旋转状态，瞬间的力会很大的，伤减速机。
Confirm that the mixing tank is in the stop state, because if the tank is in the high-speed rotation state when the engine is started, the instantaneous force will be great and damage the reducer.
无论是将手柄从搅拌到排放还是从排放到搅拌，都应使其停止在停止位置，然后拨到下一个操作位置。
Whether the handle is from mixing to discharge or from discharge to mixing, stop it at the stop position, and then turn it to the next operation position.
The above is Zhongke concrete mixer https://www.cnzkjf.com.Thank you for checking the information of our company in your busy schedule. If you want to know more, you are welcome to call for consultation!
