如何防止自动上料搅拌车在冬季结冰？我们今天就来看看吧。
How to prevent the automatic loading mixer from freezing in winter? Let's take a look today.
自动上料搅拌车在冬季运行期间需要额外的保护，因为冬季温度相对较低，长期零温度实际上对整个搅拌机非常不利。这是一个条件。如果没有增强自给式搅拌机的维护，搅拌机将冻结，因此预计冬季会有以下五点。
The automatic feeding mixer needs additional protection during winter operation, because the temperature in winter is relatively low, and the long-term zero temperature is actually very unfavorable to the whole mixer. This is a condition. Without enhanced self-contained mixer maintenance, the mixer will freeze, so the following five points are expected in winter.
在冬季，自动上料搅拌车在冬季“冻结”，自动上料搅拌车在冬季“冻结”。
In winter, the automatic feeding mixer truck is "frozen" in winter, and the automatic feeding mixer truck is "frozen" in winter.
一，制动系统
1、 Braking system
请注意制动液的数量和质量，并根据需要添加或更换。根据需要清洁整个制动系统。
Please pay attention to the quantity and quality of brake fluid and add or replace it as needed. Clean the entire brake system as required.
二，轮胎
2、 Tyre
冬季橡胶变得坚硬且相对脆弱，但它不仅减少了摩擦系统，而且在其他季节也会泄漏。在冬季，始终清洁自动上料搅拌车的轮胎内含物，避免多次使用它来修理轮胎，并务必更换不同型号或企业的轮胎。
Rubber becomes hard and relatively fragile in winter, but it not only reduces the friction system, but also leaks in other seasons. In winter, always clean the tire contents of the automatic feeding mixer truck, avoid using it to repair the tire many times, and be sure to replace tires of different models or brands.
三，热身
3、 Warm up
在冬季，温度低，润滑油的粘度不流动，发动机启动后发动机保持在1100转/分钟左右。在混合器预热后，加速器猛烈启动，发动机转速不会增加太多。只要噪声指针温度计开始上升，的温度预热就不必等待发动机温度上升。
In winter, the temperature is low and the viscosity of lubricating oil does not flow. After the engine is started, the engine remains at about 1100 rpm. After the mixer is warmed up, the accelerator starts violently and the engine speed will not increase too much. As long as the noise pointer thermometer starts to rise, the warm-up temperature of the engine does not have to wait for the engine temperature to rise.
四，打蜡
4、 Waxing
随着冬季的到来，磨砂装载机的自给式搅拌机数量也将减少，因此早冬蜡是一种更好的保养涂层。另外，身体不容易暴露在水中，冬天不容易在冰上凝结。
With the advent of winter, the number of self-contained mixers of frosting loader will also be reduced, so early winter wax is a better maintenance coating. In addition, the body is not easy to be exposed to water, and it is not easy to condense on ice in winter.
5，刹车
5. Brake
虽然冬季驾驶刹车强调“早”和“软”这两个词，但在冬季和其他季节，即使在雪地或冰路上，制动效果也不尽相同。如果与块式制动器结合使用，混合器制动灯应该更快。在冰面上，使用挡块来保持发动机制动而不是在道路上制动。如有必要，您也可以使用手制动器，但停止制动按钮以放松并且不要松开手制动器。请记住应用制动器以防止其冻结且制动器不起作用。
Although the words "early" and "soft" are emphasized in driving and braking in winter, the braking effect is different in winter and other seasons, even on snow or ice. If used in combination with a block brake, the mixer brake light should be faster. On ice, use stops to keep the engine braking instead of braking on the road. You can also use the handbrake if necessary, but stop the brake button to release and do not release the handbrake. Remember to apply the brake to prevent it from freezing and the brake does not work.
用自动上料搅拌车修正土壤残渣的方法
Method for correcting soil residue with automatic feeding mixer
自动上料搅拌车等混凝土机械在长期使用过程中不可避免地会出现一些故障。这时，我们需要对机械土渣进行一定的清洁工作。那么让我们仔细看看如何正确清理土壤。
Some faults will inevitably occur in the long-term use of concrete machinery such as automatic loading mixer. At this time, we need to clean the mechanical soil residue. So let's take a closer look at how to clean the soil correctly.
1.准备应急驱动软管，关闭自动上料搅拌车，然后拆下液压马达上的高压油管接头。
1. Prepare the emergency drive hose, close the automatic feeding mixer, and then remove the high-pressure oil pipe connector on the hydraulic motor.
2，救援车关闭，液压马达的高压油管被拆除，故障车辆上的相应连接器与应急驱动软管连接。
2. The rescue vehicle is closed, the high-pressure oil pipe of the hydraulic motor is removed, and the corresponding connector on the faulty vehicle is connected with the emergency drive hose.
3.启动救援车并将其手柄转到卸货位置。故障车辆内的混凝土排出。
3. Start the rescue vehicle and turn its handle to the unloading position. The concrete in the failed vehicle is discharged.
The wonderful content of this article is provided by Zhongke self feeding mixer truck. There are many wonderful contents on this website. You can click to enter more contents: https://www.cnzkjf.com We have special customer service to answer your questions
