混凝搅拌机是一种将水泥、砂石骨料和水混合制成混凝土混合物的机器。它主要由搅拌筒、进出料机构、供水系统、原动机、减速器、传动机构、机架和支撑装置组成。
A concrete mixer is a machine that mixes cement, aggregate and water into a concrete mixture. It is mainly composed of mixing drum, feeding and discharging mechanism, water supply system, prime mover, reducer, transmission mechanism, frame and supporting device.
主要类别
Main categories
根据混合原理：
According to the mixing principle:
(1)自动搅拌机；
(1) Automatic mixer;
(2)强制混合器。
(2) Force mixer.
根据混合桶的形状：
According to the shape of the mixing barrel:
(1)滚筒式；
(1) Roller type;
(2)锥形；
(2) Cone;
(3)盘式。
(3) Disc.
根据工作性质：
According to the nature of the work:
(1)周期性工作混合器；
(1) Periodic working mixer;
(2)连续工作搅拌机。
(2) Continuous working mixer.\
有关注意事项
Notes
1混凝土搅拌机在上班前应实施二次漏电保护，电源接通后，必须认真检查，空试合格后，方可使用。
1. The concrete mixer shall be provided with secondary leakage protection before going to work. After the power supply is connected, it must be checked carefully. It can only be used after the air test is qualified.
2启动后，注意混凝土搅拌机各部件运转是否正常。
2. After start-up, pay attention to whether all parts of the concrete mixer operate normally.
停机时，检查混凝土搅拌机的叶片是否弯曲，螺钉是否断裂或松动。
When stopping the machine, check whether the blades of the concrete mixer are bent and whether the screws are broken or loose.
3检查变速器离合器和制动器是否灵活可靠，钢丝绳是否损坏，履带滑轮是否完好，周围是否无障碍物，各部件润滑情况等。
3 check whether the transmission clutch and brake are flexible and reliable, whether the steel wire rope is damaged, whether the track pulley is in good condition, whether there is no obstacle around, and the lubrication condition of all parts.
4混凝土搅拌机应设置在平放位置，用木垫在车轴前后，使轮胎放在高处架空，以免启动时行走。
4. The concrete mixer shall be set in the flat position, with wood pad in front and back of the axle, so that the tire is placed on the high place and overhead, so as to avoid walking when starting.
5工作后，当机器不使用时，请关闭电源并锁定开关盒，以确保。
5 after operation, when the machine is not in use, please turn off the power and lock the switch box to ensure safety.
维护保养
Maintenance
混凝土搅拌机运行过程中，检查电机、减速机、传动齿轮的噪音是否正常，温升是否过高。
During the operation of concrete mixer, check whether the noise of motor, reducer and transmission gear is normal and whether the temperature rise is too high.
保持机体清洁，机体上的灰尘和障碍物。
Keep the body clean and remove dust and obstacles from the body.
检查各润滑部位的油、电路和控制设备，并按要求添加润滑油。
Check the oil, circuit and control equipment of each lubricating part, and add lubricating oil as required.
每次轮班后，混凝土搅拌机应仔细清洗。
The concrete mixer shall be carefully cleaned after each shift.
This article is provided by Zhongke Jufeng mixer. I hope it can help you. If you want to know more, please leave a message on the website http://www.cnzkjf.com.
