混凝搅拌机是一种将水泥、砂石骨料与水混合，再将、混合制成混凝土混合物的机器。主要由搅拌筒、进出料机构、供水系统、原动机、减速器、传动机构、齿条及支撑装置等组成。
The concrete mixer is a kind of machine that mixes cement, aggregate and water, and then mixes them into concrete mixture. It is mainly composed of mixing drum, feeding and discharging mechanism, water supply system, prime mover, reducer, transmission mechanism, rack and support device, etc.
主要类别
Main categories
根据混合原理：
According to the mixing principle:
(1)自动搅拌机；
(1) Automatic mixer;
(2)强制混合器。
(2) Force mixer.
根据混合桶的形状：
According to the shape of the mixing barrel:
(1)滚筒式；
(1) Roller type;
(2)锥形；
(2) Cone;
(3)盘式。
（3） Disc.
根据工作性质：
According to the nature of the work:
(1)周期性工作混合器；
(1) Periodic working mixer;
(2)连续工作搅拌机。
(2) Continuous working mixer.
有关注意事项
Notes
1混凝土搅拌机应进行二次防漏保护。上班前接通电源后，必须仔细检查。混凝土搅拌机只有通过空车试运行后才能使用。
1. The concrete mixer shall be provided with secondary leakage protection. After connecting the power supply before going to work, it must be checked carefully. The concrete mixer can only be used after the test run of empty truck.
2启动机器后，注意混凝土搅拌机各部分的正常运转。
2 after starting the machine, pay attention to the normal operation of each part of the concrete mixer.
停机时，检查混凝土搅拌机的叶片是否弯曲，螺钉是否断裂或松动。
When stopping the machine, check whether the blades of the concrete mixer are bent and whether the screws are broken or loose.
3检查变速器离合器和制动器是否灵活可靠，钢丝绳是否损坏，履带滑轮是否完好，周围是否无障碍物，各部件润滑情况等。
3 check whether the transmission clutch and brake are flexible and reliable, whether the steel wire rope is damaged, whether the track pulley is in good condition, whether there is no obstacle around, and the lubrication condition of all parts.
4混凝土搅拌机应设置在平坦的位置，前后轴应垫以方木，使轮胎高且在上方，以避免启动时行走。
4. The concrete mixer shall be set in a flat position, and the front and rear axles shall be padded with square wood to make the tire high and above, so as to avoid walking when starting.
5下班后，机器不使用时，请关闭电源并锁好开关箱，以确保。
5 after work, when the machine is not in use, please turn off the power and lock the switch box to ensure safety.
维护与保养
Maintenance and service
混凝土搅拌机运行过程中，检查电机、减速机、传动齿轮的噪音是否正常，温升是否过高。
During the operation of concrete mixer, check whether the noise of motor, reducer and transmission gear is normal and whether the temperature rise is too high.
保持机体清洁，机体上的灰尘和障碍物。
Keep the body clean and remove dust and obstacles from the body.
检查各润滑部位的油、电路和控制设备，并按要求添加润滑油。
Check the oil, circuit and control equipment of each lubricating part, and add lubricating oil as required.
每次轮班后，混凝土搅拌机应仔细清洗。
The concrete mixer shall be carefully cleaned after each shift.
This article is compiled by Zhongke Jufeng concrete mixer. If you want to know more information about concrete mixer, please consult the official website http://www.cnzkjf.com 。
